CCMS Power Supply

Single Phase CAFK050300 AC - DC Power Supply.

GENERAL

SCOPE
This Specification defines the performance characteristics of SMPS based 15W AC-DC Adaptor.

SPECIFICATION

INPUT CHARACTERISTIC

INPUT OPERATING VOLTAGE
140VAC - 300VAC.
INPUT FREQUENCY
45Hz to 65Hz.
INRUSH CURRENT
<25A Peak @ 230VAC, Cold start @ 25ºC.
INPUT CURRENT
< 0.25A RMS @140VAC.
EFFICIENCY
>70% Under Maximum load @ 230VAC.

OUTPUT CHARACTERISTIC:

OUTPUT VOLTAGE
4.80VDC to 5.10VDC.
OUTPUT CURRENT
3.0A Cont.
RIPPLE
< 100mV. Pk-Pk.
NOISE
< 150mV. Pk-Pk.
OUTPUT OVER CURRENT
> 3.0A to < 5.0A .

PROTECTIONS:

OVER TEMPERATURE PROTECTION
The Power supply is protected against over temperature. In case of PROTECTION over temperature the power supply goes to latch mode. the might be return to normal state by AC recycle. This is provided with a large hysteresis to avoid the PCB board over heating incase of fault conditions. the shutdown threshold at the case of Internal Room Ambient Temperature is >70ºC.
OUTPUT OVERLOAD / SHORT CIRCUIT PROTECTION
The power supply is protected against over load & short circuit . During over load & Short circuit the power supply will go to hick up mode and resumes to normal operation on removal of fault condition.
INPUT HIGH VOLTAGE PROTECTION
The Power Supply is protected against input high voltage so it can withstand up to 510VAC supply.

ENVIRONMENT

TEMPERATURE
Operating Ambient 0ºC to + 50ºC.
Storage -15ºC to +70ºC ambient.
HUMIDITY
Operating 5% RH to 95% RH non - condensing.
Storage 5% RH to 95% RH non- condensing.

SURGE PROTECTION:

As per Test Standard IEC61000 - 4 - 5.
4KV With stand.

PRODUCT SAFETY:

DI-ELECTRIC VOLTAGE WITHSTAND TEST
1.50KVAC RMS, 50Hz for one minute (trip current set at 5mA) Between Shorted Input and Output terminals.
INSULATION RESISTANCE WITHSTAND TEST
When tested with 500VDC Megger shall be >100M ohms Between Shorted Input and Output terminals.

INDICATIONS:

Red LED provided to indicate the power supply ON.

TERMINATIONS:

AC Input
Input 2core, 0.2Mtr length cable open wires.
DC Output
Output 2core 0.2Mtr length cable open wires.

MECHANICAL:

ENCLOSURE DIMENSIONS
Length: 125mm, Width: 60.00mm, Height: 32.0mm.